|
- Check battery (Refer to GROUP 54A - Battery - On-vehicle Service - Battery Test
).
|
|
Q.
Is the check result normal?
|
|
Q.
Is diagnosis code stored?
|
|
Inspection chart for diagnosis code (Refer to ).
|
|
|
|
- Refer to Data List Reference Table
.
- Item 5: Intake air temperature sensor
- Item 6: Engine coolant temperature sensor
- Item 8: Manifold absolute pressure sensor
- Item 10: Air flow sensor
- Item BB: Barometric pressure sensor
|
|
Q.
Are the check results normal?
|
|
Perform the diagnosis code classified check procedure for the sensor that has shown an abnormal data value (Refer to Inspection Chart for Diagnosis Code ).
|
|
|
|
Q.
Is the check result normal?
|
|
Clean throttle body (throttle valve portion) (Refer to ).
|
|
|
|
OK: Operating sound of fuel pump can be heard.
|
|
Q.
Is the check result normal?
|
|
Check Inspection Procedure - fuel pump system (Refer to ).
|
|
|
|
Q.
Is the check result normal?
|
|
- Check injector for operating sound at engine cranking (Refer to
).
|
|
Q.
Is operating sound audible?
|
|
Check the injector system of the defective cylinder. Check code No. P0261: No. 1 injector circuit low input (Refer to ). Check code No. P0262: No. 1 injector circuit high input (Refer to ). Check code No. P0264: No. 2 injector circuit low input (Refer to ). Check code No. P0265: No. 2 injector circuit high input (Refer to ). Check code No. P0267: No. 3 injector circuit low input (Refer to ). Check code No. P0268: No. 3 injector circuit high input (Refer to ). Check code No. P0270: No. 4 injector circuit low input (Refer to ). Check code No. P0271: No. 4 injector circuit high input (Refer to ).Check code No. P0273: No. 5 injector circuit low input (Refer to ). Check code No. P0274: No. 5 injector circuit high input (Refer to ).Check code No. P0276: No. 6 injector circuit low input (Refer to ). Check code No. P0277: No. 6 injector circuit high input (Refer to ).
|
|
|
|
Q.
Is the check result normal?
|
|
- Remove the spark plug and install it to the ignition coil.
- Connect the ignition coil connector.
- Remove all injector connectors.
- At the engine start, check each spark plug produces a spark.
|
|
Q.
Is the check result normal?
|
|
Check Inspection Procedure - ignition circuit system (Refer to ).
|
|
|
|
- Check each injector for spray condition (Refer to
).
|
|
Q.
Is the check result normal?
|
|
- Fuel pressure measurement (Refer to
).
|
|
Q.
Is the check result normal?
|
|
- Check the compression pressure (Refer to GROUP 11C - On-vehicle Service - Compression Pressure Check
).
|
|
Q.
Is the check result normal?
|
|
- After the engine-ECU has been replaced, check for the trouble symptom again.
|
|
Q.
Does the trouble symptom persist?
|
|
Check for foreign matters (water, kerosene, etc.) in fuel and replace if necessary.
|
|
|